Owner's Manual with Assembly InstructionsFor Model 73510®Product features and decoration may vary from the picture above.Please read this manual
Battery Charging• Plug the charger into a standard 120 volt wall outlet.Note: If power flow to the wall outlet is controlled by a switch,make sure the
11• Turn the vehicle body upright.• Using safety scissors, cut the plastic retainer holding the gearbox in place.• Throw away the plastic retainer.2•
Assembly124• Fit the lock washer (rounded side up) into the assemblytool. Make sure it completely fits inside the assembly tool.• Position the rear ax
Assembly139• Fit the driver onto the end of the rear axle.• Align the ribs on the inside of the driver with the gearboxteeth. Fit the driver to the ge
15Assembly• Insert eight #8 x 3/4" screws into the door, as shown.• Tighten the screws with a Phillips screwdriver. Do not over-tighten.• Turn th
Assembly• Insert two #8 x 3/4" screws through the windshield hinge andinto the windshield. • Tighten the screws with a Phillips screwdriver. Do n
16Assembly• Slide a large washer onto theshort end of each front axle.• Position the steering linkagecover over the steering linkage.Make sure the A a
17Assembly• Fit a .437 white cap nut onto the end of a front axle. • Tap the cap nut with a hammer to secure it to the end of thefront axle.• Repeat t
Assembly30Bottom View• Fit the wheel (with a round bushing and hex bushinginserted) onto the end of the front axle. Make sure theoutside of the wheel
Assembly• Cut the steering wheel labels (#13, #14 and #15) from thelarger label sheet. Now, position the steering wheel labels, as shown in the illust
2Table of ContentsImportant InformationA Important Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Assembly• Turn the vehicle body on its side, so that the bottom faces you.• Position the steering bracket behind the steering linkage, as shown.• Fit
AssemblyIMPORTANT! Please carefully read the owner’s information in this manual and teach your child about proper vehicleoperation and rules for safe
TM1Front / Right Side View 22Proper label application will help to keep the labels looking their best! When applying labels, keep the followingguideli
Label Decoration2Front / Left Side ViewRear View3231616173372091820819122214Fun GraphicsRace Graphics212526273132302928Note: We’ve included custom lab
®®24IMPORTANT! Use only a Power Wheels®Type H 6 volt batterywith a Power Wheels®25 Amp fuse installed. Use of any otherbattery or fuse will damage you
®25• Plug the battery connector into the motor harness connector.Note: If the battery connector will not plug into the motorharness connector, turn it
If a battery leak develops, avoid contact with the leakingacid and place the damaged battery in a plastic bag. See information below for proper dispos
27Teach Safety Rules to ChildrenWhile children can quickly develop the skill necessary to drivethis vehicle, it is important to remember that their ju
How to Operate Your Vehicle• Press the FORWARD button below the seat.• Press the foot pedal . The vehicle will drive forward at amaximum of 2.5 mph
Problems and Solutions GuideIMPORTANT! If you experience a problem with your vehicle, first check the Problems and Solutions Guidebelow. If you still
CAUTION• In the unassembled state, this package contains small parts. Adult assembly is required.• Use the charger in dry locations only.WARNING• Prev
30Problems and Solutions GuideVehicle does not run (con’t.) Loose wire or loose connectors Check all wires and connectors. Make sure the motor harness
31If, after reviewing the Problems and Solutions Guide, the vehicle still fails to operate, please contact your nearest authorized service center or c
Authorized Service CentersPWe are continually expanding our Authorized Service Center Network. Please check this listingfor the Authorized Service Cen
Authorized Service Centers33CHICAGO (MORTON GROVE) - Brand Service Center,Inc., 5618 Dempster Street, 60053, (847) 965-5900DECATUR - Rexx Battery of D
Authorized Service Centers34NEW HAMPSHIREMARLBOROUGH - Electronics Aid Inc., 32 RoxburyRoad P.O.Box 325, 03455, (603) 876-4161NEW JERSEYDENVILLE- Ranf
Authorized Service Centers35KNOXVILLE - Authorized Appliance Service Center,1206 North Central Street, 37917, (865) 524-3376MEMPHIS - Camp Electric Co
Printed in U.S.A. 73510pr-0920If you are missing parts or need assistance,please call us toll-free:Power Wheels®Consumer Relations1-800-348-07518 AM -
PartsCWheel - 4• If you experience a problem with this product, or are missing a part, please call us at 1-800-348-0751, rather than return thisproduc
Steering LinkageSteering Linkage CoverPartsNot Shown: Label Sheet - 2SpacerHex Bushing - 4Round Bushing - 6525 Amp Fuse - 1**Note: For your convenienc
PartsAll Shown Actual SizeLock Washer - 4**Note: For your convenience, an extra .437 white cap nut, .354 black cap nut and lock washer are included.6.
TM®IMPORTANTA 25 AMP FUSE MUSTBE INSTALLED IN TOPOF BATTERY BEFORETOY WILL RECHARGEOR OPERATEParts DiagramD2222222020202127626283623114410161617181818
Battery ChargingE8CAUTIONUse the charger in dry locations only.WARNING• Battery can fall out and injure a child if vehicle tips over. Always use batte
Battery Charging9®• Locate the lock fasteners in the back of the seat.• Using a slotted screwdriver, turn each lock fastener 1/4turn to the unlocked
Comments to this Manuals