Owner’s Manual with Assembly InstructionsPlease read this manual and save it with your original sales receipt.For Model 78477Tools needed for assembly
CAUTIONUse the charger in dry locations only.Battery ChargingEWARNING• The battery must be handled by adultsonly. The battery is heavy and containssul
Battery ChargingPb• Plug the charger connector into the battery .• Plug the charger into a standard 120 volt wall outlet .Note: If power flow to the
4DashKnob PlateKey Assembly• Snap the dash knobs into the knob plate. (See inset.)Note: Gently squeeze the tabs on the knobs togetherbefore inserting
2030406070809010011012001050MPH0123456RPM x 1000EFTEMP100210260®LO KCHIREV FWDTREBIGNITION69Steering WheelCap NutSteering Column“UP”Tab• Turn the vehi
13• Fit the lens tabs on the back of a lens assembly into theheadlight slots in the grille.• Press firmly to snap the lens assembly into the grille.•
• Insert a hood latch into one of the holes in the vehiclebody, near the hood area.• Twist the base of the hood latch 1/4turn to secure it in thevehic
• Fit the back half of the windshield frame onto the fronthalf of the windshield frame. Make sure the slots at thebottom of the two windshield frame h
Hood TabsSlotSlot• Position the hood over the front of the vehicle body.• Insert the tabs on the hood into the slots in the vehicle body.Lights andSir
• Insert each end of the long seat belt strap through a slotin the center of the seat. Make sure the fasteners facethe outer edge of the seat.• Pull e
323031• Extend the canopy completely around the sport bar.Sport BarCanopy• Using safety scissors, remove the sport bar brackets fromthe plastic connec
2Table of ContentsImportant InformationA Important Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
KCTMLight Covers35• Fit the sport bar and sport bar support legs into the holesin the vehicle body.• Push down firmly on a sport bar side leg while pu
2139Assembly40TaillightLensTaillight HousingRear Bumper Light Plate38• Lift the rear of the vehicle.• Align the holes in the bumper tabs with the scre
™™Label Decoration22G™®™™Proper label application will help to keep the labels lookingtheir best! When applying labels, keep the followingguidelines i
PbBattery InstallationHImportant Note: Use only a Power Wheels®12 volt battery.Use of any other battery will damage your vehicle. Makesure that you ch
Battery Care and DisposalBattery Care and DisposalIIf a battery leak develops, avoid contact with the leakingacid and place the damaged battery in a p
25Rules for Safe DrivingJ5. Do not operate this vehicle with more than two riders;one driver and one passenger seated in the seatingarea. A child who
26How to Operate Your VehicleK• Make sure the shifter is in the low speed ( ) position .• Press down on the foot pedal . The vehicle goes forwardat a
27To DriveCaring For Your VehicleLAdvanced Use - High Speed Drive• Check all nuts, bolts, and their protective coveringsregularly and tighten as requi
28Problems and Solutions GuideIMPORTANT! If you experience a problem with your vehicle, first check the Problems and SolutionsGuide below. If you stil
29Problems and Solutions GuideVehicle was running but Loose wire or loose connectors Check all wires and connectors. Make sure the motorsuddenly stopp
3WARNING• Children can be harmed by small parts, sharp edges and sharp points in the vehicle’sunassembled state, or by electrical items. Care should b
30Problems and Solutions GuideProblem Possible Cause SolutionVehicle runs sluggishly Undercharged battery Charge the battery. A new battery should hav
If, after reviewing the Problems and Solutions Guide, the vehicle still fails to operate, please contact your nearest authorized service center (see p
Bumper-to-Bumper* Limited WarrantyNAuthorized Service CentersO*One year limited warranty from the date ofpurchase on the Power Wheels®vehicle.Six mont
Authorized Service Centers33DELAWARESELBYVILLE - Ahern & Son, Inc., #2 S. Dupont Hwy Rt. 2,19975, (302) 436-4100WILMINGTON - Lyons Hardware Do-It
Authorized Service Centers34MICHIGANALMONT - Almont Do It Center #421, 4545 Van Dyke,48003, (810) 798-8922BAY CITY - Bay Vac & Pedal, 805 Columbus
Authorized Service Centers35OKLAHOMAMC ALESTER - Quality Upholstery, 803 E. Gene StipeBlvd., 74501, (918) 423-4747OKLAHOMA CITY - Brand Appliance Repa
JEEP and the Jeep grille design are registered trademarks of DaimlerChrysler Corporation and are used under license.©DaimlerChrysler CorporationFisher
4PartsC• If you experience a problem with this product, or are missing a part, please call us at 1-800-348-0751, rather than returnthis product to the
5PartsSteering Wheel CapKnob PlateHood Latch – 2Dash Knob – 2Rear BumperKey AssemblyNot Shown: Label Sheet, Literature BagSteering ColumnCap Nut – 3*D
6CanopyWater JugWater Jug HolderRight SidepipeLeft SidepipePartsSport Bar Sport Bar Support - 2Sport Bar Bracket SetWindshield Frame - FrontWindshield
PartsLights and Siren#6 x7/16" Screw – 2#6 Washer - 2MicrophoneThese components are found in the Lights and Siren Box#8 x 1" Screw – 14#10 x
123465101817191515474728491020213313130252738264150713503414403913131284344946484816114542333233102924372322363332351010108Parts DiagramDD
Parts Diagram9No. Part Quantity1 Vehicle Body 12 Steering Column 13 .354 Cap Nut 24 Hood Latch 25 12 Volt Battery 16 Battery Retainer 17 #8 x 4"
Comments to this Manuals